March 4, 2022

International Benchmarks for Corn Production (2022)

by Michael Langemeier and Leying Zhou

Examining the competitiveness of corn production in different regions of the world is often difficult due to lack of comparable data and agreement regarding what needs to be measured. To be useful, international data needs to be expressed in common production units and converted to a common currency. Also, production and cost measures need to be consistently defined across production regions or farms.

This paper examines the competitiveness of corn production for important international corn regions using 2016 to 2020 data from the agri benchmark network. An earlier paper examined international benchmarks for the 2015 to 2019 period (Langemeier, 2021). The agri benchmark network collects data on beef, cash crops, dairy, pigs and poultry, horticulture, and organic products. There were 16 countries with corn data for 2020 represented in the cash crop network. The agri benchmark concept of typical farms was developed to understand and compare current farm production systems around the world. Participant countries follow a standard procedure to create typical farms that are representative of national farm output shares, and categorized by production system or combination of enterprises and structural features. Costs and revenues are converted to U.S. dollars so that comparisons can be readily made. Data from six typical farms with corn enterprise data from Argentina, Brazil, Russia, Ukraine, and United States were used in this paper. It is important to note that corn enterprise data is collected from other countries. These five countries were selected to simplify the illustration and discussion.

The farm and country abbreviations used in this paper are listed in table 1. While the farms may produce a variety of crops, this paper only considers corn production. Typical farms used in the agri benchmark network are defined using country initials and hectares on the farm. To fully understand the relative importance of the corn enterprise on each typical farm, it is useful to note all of the crops produced. The typical farm in Argentina produced corn, soybeans, sunflowers, and winter wheat in 2020. Corn was produced on approximately 11 percent of the typical farm’s acreage during the five-year period. The typical farm in Brazil produced corn and soybeans in 2020. Corn was a second crop following soybeans and was produced on approximately 78 percent of the typical farm’s acreage during the five-year period. The farm in Russia produced alfalfa, chickpeas, corn, corn silage, fodder grass, soybeans, summer barley, sugar beets, sunflowers, winter rye, and winter wheat in 2020. Corn was produced on approximately 12 percent of the typical farm’s acreage during the five-year period. Crops produced on the farm in the Ukraine in 2020 included corn, soybeans, sunflowers, winter rapeseed, and winter wheat. Corn was produced on approximately 26 percent of the typical farm’s acreage during the five-year period. There are five U.S. farms with corn in the network. The two farms used to illustrate corn production in this paper are the Iowa typical farm (US700) and the west central Indiana typical farm (US1215). Both of these farms utilize a corn/soybean rotation.

Table 1. Abbreviations of Typical Farms.

Table 1. Abbreviations of Typical Farms.

Corn Yields

Although yield is only a partial gauge of performance, it reflects the available production technology across farms. Average corn yield for the farms in 2016 to 2020 was 8.66 metric tons per hectare (137.9 bushels per acre). Average farm yields ranged from approximately 5.98 metric tons per hectare for the Russian farm (95.3 bushels per acre) to 12.63 metric tons per hectare for the Iowa farm (201.2 bushels per acre). Figure 1 illustrates average corn yield for each typical farm. Both of the U.S. farms had average corn yields above 11.5 metric tons per hectare (183 bushels per acre).

Figure 1. Average Corn Yield (metric tons per hectare)

Figure 1. Average Corn Yield (metric tons per hectare)

Input Cost Shares

Due to differences in technology adoption, input prices, fertility levels, efficiency of farm operators, trade policy restrictions, exchange rate effects, and labor and capital market constraints, input use varies across corn farms. Figure 2 presents the average input cost shares for each farm. Cost shares were broken down into three major categories: direct costs, operating costs, and overhead costs. Direct costs included seed, fertilizer, crop protection, crop insurance, and interest on these cost items. Operating cost included labor, machinery depreciation and interest, fuel, and repairs. Overhead cost included land, building depreciation and interest, property taxes, general insurance, and miscellaneous cost.

The average input cost shares were 41.2 percent for direct cost, 32.2 percent for operating cost, and 26.6 percent for overhead cost. The typical farms in Russia, Ukraine, and Iowa had below average cost shares for direct cost. All of the farms except the typical farm in Russia and the typical farm in Ukraine had below average cost shares for operating cost. Labor costs as a proportion of total costs were relatively higher for the typical farms in Russia and the Ukraine. Overhead costs as a proportion of total costs were relatively higher in Argentina and the United States. The relatively large cost share for overhead cost in the U.S. reflects our relatively high land cost. Land cost accounted for approximately 32 percent of total cost for the two U.S. typical farms.

Figure 2. Average Cost Shares for Corn

Figure 2. Average Cost Shares for Corn

Revenue and Cost

Figure 3 presents average gross revenue and cost for each typical farm. Gross revenue and cost are reported as U.S. dollars per hectare. It is obvious from figure 3 that gross revenue per hectare is substantially higher for the two U.S. farms. However, cost is also substantially higher for these two farms. The typical farms from Argentina and Ukraine exhibited economic profit during the five-year period. Average losses during the five-year period for the typical farms from Brazil and Russia were $46 and $10, respectively. The typical farm in Iowa and the typical farm in west central Indiana exhibited averages losses of $178 and $147 per hectare, respectively, during the five-year period. The lowest economic profit during the five-year period for the typical farms was 2017 with an average loss of $141 per hectare, while the highest average economic profit ($120 per hectare) occurred in 2016. The lowest economic profit for each typical farm was as follows: 2016 for the Iowa farm; 2017 for the typical farms in Brazil, Russia, Ukraine, and western Indiana; and 2020 for the typical farm in Argentina.

Figure 3. Average Gross Revenue and Cost for Corn ($ per hectare)

Figure 3. Average Gross Revenue and Cost for Corn ($ per hectare)

Figure 4 presents average gross revenue and cost for corn on a per ton basis. Gross revenue per ton was relatively higher for the typical farm in the Ukraine and the two typical U.S. farms. However, the two U.S. typical farms also had relatively higher costs per ton. Economic profit for the five-year period was positive for the typical farms in Argentina and Ukraine.

Figure 4. Average Gross Revenue and Cost for Corn ($ per ton)

Figure 4. Average Gross Revenue and Cost for Corn ($ per ton)

Conclusions

This paper examined yield, gross revenue, and cost for farms in the agri benchmark network from Argentina, Brazil, Russia, the Ukraine, and the United States with corn enterprise data. Yield, gross revenue, and cost were substantially higher for the U.S. farms. The typical farms in Argentina and Ukraine exhibited a positive average economic profit during the 2016 to 2020 period. The data for 2021 will be available early this fall. Once the 2021 data is added to the five-year averages, economic profit will increase for the two U.S. farms. Whether this will change relative competitiveness is an open question at this point.

 


References

agri benchmark. http://www.agribenchmark.org/home.html. Accessed on February 24, 2022.

Langemeier, M. “International Benchmarks for Corn Production.” Center for Commercial Agriculture, Purdue University, June 4, 2021.

TAGS:

TEAM LINKS:

RELATED RESOURCES

Crop Basis Tool

March 24, 2023

The Purdue Center for Commercial Agriculture Crop Basis Tool is a web-based tool that provides access to weekly historical and contemporaneous corn and soybean basis data for local market regions in the eastern corn belt.

READ MORE

2023 Crop Cost and Return Guide

March 24, 2023

The Purdue Crop Cost and Return Guide offers farmers a resource to project financials for the coming cropping year. These are the March 2023 crop budget estimations for 2023.

READ MORE

2023 Indiana Farm Custom Rates

March 24, 2023

The rates reported in this publication were compiled from questionnaires received from farmers, farm owners, farm custom operators, and professional farm managers in Indiana. Purdue Extension Educators distributed the questionnaires at meetings and events statewide during the last month of 2022 and the first three months of 2023. Respondents were asked to report custom rates they had either paid or received during the past year.

READ MORE

UPCOMING EVENTS

Monthly Corn & Soybean Outlook Update

Webinar each month following USDA’s release of the updated World Agricultural Supply and Demand Estimates (WASDE). Catch the next monthly update on April 1 for the corn and soybean outlook following release of USDA’s Prospective Plantings reports. Registration is free.

Read More

2023 Crop Cost and Return Guide

March 24, 2023

The Purdue Crop Cost and Return Guide offers farmers a resource to project financials for the coming cropping year. These are the March 2023 crop budget estimations for 2023.

READ MORE

2023 Indiana Farm Custom Rates

March 24, 2023

The rates reported in this publication were compiled from questionnaires received from farmers, farm owners, farm custom operators, and professional farm managers in Indiana. Purdue Extension Educators distributed the questionnaires at meetings and events statewide during the last month of 2022 and the first three months of 2023. Respondents were asked to report custom rates they had either paid or received during the past year.

READ MORE

Making Your 2023 Crop Insurance Decision

February 24, 2023

Now is a great opportunity for producers to review their crop insurance choices for the upcoming season. Purdue University Center for Commercial Agriculture’s ag economists Michael Langemeier and James Mintert walk participants through key considerations for their 2023 insurance options. In particular, they discuss a handy thumb rule to use when considering an increase in coverage levels for RP insurance.

READ MORE